2010 HYUNDAI SANTA FE Fuel System, Gasoline problems & defects.

HYUNDAI SANTA FE Fuel System, Gasoline problems : 5.

Gas/fuel Smell Coming From Engine Compartment Into Cabin Of 2010 hyundai santa Fe Gls (2.4 L Automatic). Smell Is Not Noticeable At Cold Start Overnight, Or After A Couple Of Hours Of Sitting. Smell Is Very Noticeable After The Vehicle Is Driven To Operating Temperature And Then Shut Off For Anywhere From 10 Minutes To An Hour. The fuel Smell Comes Directly Into The Cabin When The Hvac System Is Set To Vent, But Not On Recirculate. Dealer Has Removed And Replaced fuel Injectors And fuel Rail. Smell Still Persists. This Is A Daily Occurrence. The Smell Also Occurs When Stopped For Any Amount Of Time While Driving/idling. The Smell Occurs When The Vehicle’s Engine Is Off, But The Key Is Turned To The Point The Hvac Will Turn On. This Means The Smell Occurs Regardless Of Whether The Engine Is Running Or Not. The Smell Accumulates Under The Hood And Is Strongest Near The Passenger Side Middle. The Smell Is Bad Enough To Permeate Clothes While Driving And To Be Smelled Inside The House When The Door To The Garage Is Opened. It’s Bad Enough To Force Parking The Vehicle Outdoors. It Appears This Issue Is Being Discussed On The hyundai Forums Website And Most Complaints Are For The hyundai Sonata And Sonata Turbo, But The Description Of The Issue And Potential Solutions Point To The Same Cause For My santa Fe. The Dealer Has Acknowledged The Smell, But Not In Writing. The Vehicle Has Been In Five Times For This Complaint – Twice With Work Done, Twice With No Work Done (claim Was Could Not Replicate), And Once I Was Sent Home Before Any Work Was Done As The Service Representative Determined There Was Nothing They Could Do At That Time. There Appears To Be No Known Solution To This Issue Coming Forth From hyundai At This Time. *tr

Mileage was 7500 miles. Vehicle Identification Number (VIN):5NMSG3AB6AH. HYUNDAI SANTA FE 2010 problem was reported in RIO RANCHO, NM. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 4 CYLINDERS. VEHICLE SPEED: 0 mph.

Apr 14, 2011

I Purchased The 2010 hyundai santa Fe New With Only 60 Miles On It In June 2010. In January 2011 We Began Smelling A fuel Smell. This Occurred Only After The Car Was Running And Shut Off Then Subsequently Turned Back On Less Than An Hour Later Like When Running Errands. I Never Smelled Gas If The Car Sat Overnight. We Also Would Experience An Intermittent Long Crank. I Brought The Car To The Dealer In January 2011 And They Replaced 2 O-rings That They Stated Were Leaking And Found fuel Around. After These Were Replaced, I Still Had The Same Problems. I Brought The Car Back In February 2011 And No Known Problems Were Found By The Dealer. Again, I Brought The Car Back In March. This Time They Found fuel In The Charcoal Canister. They Stated I Was Overfilling The Tank Which Was Why There Was fuel In The Charcoal Canister. After Speaking With The Manager, They Agreed To Cover The Part And Labor At No Charge And Replaced The Charcoal Canister. After This Was Replaced, I No Longer Experienced The Long Crank But I Still Smell Gas After Running Errands. hyundai Will Again Be Looking At The Car For Any Other Problems, But The Dealer Is Really Stumped So Far On This. *tr

Mileage was 10500 miles. HYUNDAI SANTA FE 2010 problem was reported in BECKER, MN. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.

Jan 21, 2011

When Pushing The Gas Pedal To Accelerate From Stopped Position There Is A Notable Pause. (1-3 Seconds??)this Then Causes You To Push Accelerator Further ,thereby Causing A Much More Sudden Acceleration. I Am Used To It Because It Has Happened Intermittently Since Car Was New, But Someone Could Get In Trouble. hyundai Service Says Its Because The Pedal Is Sending A Position Of Pedal Through An Electronic Signal To fuel Metering System.

0 person(s) were injured. 0 person(s) died. Mileage was 11000 miles. Vehicle Identification Number (VIN):5NMSG3AB6AH. HYUNDAI SANTA FE 2010 problem was reported in HEATHSVILLE, VA. Vehicle was not using Cruise Control. VEHICLE SPEED: 5 mph.

July 06, 2011

My santa Fe Stalled While Making A Low Speed Right Turn. No Warning The Steering Became Hard And Instrument Lights Went On And Engine Off. Started Right Up Afterwards. Immediately Took It To The Dealer Who Replace The Throttle Body And Updated Computer. No Error Codes. *tr

0 person(s) were injured. 0 person(s) died. Mileage was 41000 miles. Vehicle Identification Number (VIN):5NMSH4AG6AH. HYUNDAI SANTA FE 2010 problem was reported in REDWOOD CITY, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 15 mph.

June 10, 2013

After Coming To A Full Stop At An Intersection, I Accelerated To Enter The Intersection And Turn Right. Almost Immediately As I Pulled Into The Intersection, The Car Stalled As Though It Had Died. I Continued To Press On The Accelerator And After 3 To 4 Seconds, The Car Lurched Forward, With fuel Feed Working Normally. I Took The Car To My Local Dealer Where I Bought The Car For Inspection. They Took The Car In For Testing And Said They Could Not Find Anything Wrong. This Problem Persisted, With The Incidents Being Infrequent. I Reported This Problem Each Of The Next Few Times The Problem Recurred. Each Time I Asked If Others Had Reported The Same Problem. Each Time I Was Told There Were No Such Complaints, And That They Could Not Find A Reason For My Problem. Finally, I Left The Vehicle At The Dealer For Several Days With The Understanding That They Would Drive The Car Frequently, Trying To Duplicate My Problem. After Several Days, They Called To Say They Had Experienced The Problem As I Had Reported It, And They Had Fixed It. I Asked What Was Done, And The Agent Could/would Not Specify What The Cause Was, But They Wrote On The Invoice That They Had Reprogrammed Tcm With Tsb#11-at-011-1. I Then Again Queried About Other Complaints, And He Said That There Had Been Other Complaints After All, And This Should Fix The Problem. However, I Have Since Experienced The Problem Again And Fear That An Accident Is Possible. The Latest: They Are Taking My Vehicle In This Thursday For A Major Diagnosis “to Try To Find The Problem”., Again. *tr

0 person(s) were injured. 0 person(s) died. Mileage was 7916 miles. Vehicle Identification Number (VIN):5NMSHDAG3AH. HYUNDAI SANTA FE 2010 problem was reported in HALTOM CITY, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 5 mph.

Nov 18, 2010

2010 HYUNDAI SANTA FE problems and complaints, and up-to-date recall information. If you are researching a used HYUNDAI SANTA FE, driving a 2010 HYUNDAI SANTA FE, or if you are planning to purchase one, review owner-reported Fuel System, Gasoline problems and defects.

Post Author: hyundaiproblem

3 thoughts on “2010 HYUNDAI SANTA FE Fuel System, Gasoline problems & defects.

  • Yolanda Bangit

    (June 30, 2016 - 12:49 pm)

    In December 2015 our Hyundai Santa Fe 2010 also smelled gas while running. We brought it to Hyundai Dasmarinas and we were told that the gas tank will be replaced. In April 2016 we were surprised that the tank was not ordered and instead replaced the cap of the gas tank and told me not fill the tank in full. I complained that they made me believe that gas tank would be replaced as it is still under warranty. After a month or so again we smelled the gas and this time gas was leaking when I trief to fill up the gas tank full. I immediately brought the car to Dasmarinas branch and was told that the cap was not properly screwed last time. I left very disappointed as am afraid of my safety when leaking or smell of gas happens again

  • Yolanda Bangit

    (June 30, 2016 - 12:49 pm)

    In December 2015 our Hyundai Santa Fe 2010 also smelled gas while running. We brought it to Hyundai Dasmarinas and we were told that the gas tank will be replaced. In April 2016 we were surprised that the tank was not ordered and instead replaced the cap of the gas tank and told me not fill the tank in full. I complained that they made me believe that gas tank would be replaced as it is still under warranty. After a month or so again we smelled the gas and this time gas was leaking when I trief to fill up the gas tank full. I immediately brought the car to Dasmarinas branch and was told that the cap was not properly screwed last time. I left very disappointed as am afraid of my safety when leaking or smell of gas happens again

    • Dave Soul

      (September 4, 2017 - 11:46 am)

      I know it’s been a year since your post, but was your vehicle fixed and what did they find wrong with it?

Leave a Reply

Your email address will not be published. Required fields are marked *

You may use these HTML tags and attributes: <a href="" title=""> <abbr title=""> <acronym title=""> <b> <blockquote cite=""> <cite> <code> <del datetime=""> <em> <i> <q cite=""> <strike> <strong>